Tiguan 2016 ➤, Tiguan 2021 ➤, Tiguan RUS 2017 ➤, Tiguan RUS 2021 ➤
Maintenance - Edition 12.2020
4.12
Brake fluid level: Check
NOTICE
♦ Never allow brake fluid to come into contact with fluids
that contain mineral oils (e.g. oil, petrol, cleaning agents).
Mineral oils will damage seals and rubber grommets of
brake system.
♦ Brake fluid is poisonous. In addition, due to its corrosive ef‐
fect, brake fluid must not come into contact with paintwork.
♦ Brake fluid is hygroscopic, which means it absorbs mois‐
ture from the ambient air and should therefore always be
stored in air-tight containers.
♦ Rinse off spilled brake fluid using plenty of water.
♦ Observe relevant disposal regulations.
When replenishing, ensure to not spill any liquids in the en‐
gine compartment.
Spilled liquids may cause damage in the motor compartment.
Toothed belts, V-belts and poly V-belts which came into con‐
tact with oil, brake fluid or coolant must always be renewed.
Brake fluid level at delivery inspection
– At delivery inspection, the fluid level must be at MAX. mark‐
ing -1-.
Note
To prevent brake fluid from flowing out of the reservoir, the max.
marking -1- must not be exceeded.
Brake fluid level at inspection service
Note
♦ The fluid level must always be judged in conjunction with
lining/pad wear.
♦ When vehicle is in use, fluid level tends to drop slightly due
to lining/pad wear and automatic adjustment.
Recommended brake fluid level “before” brake pads are at wear
limit
•
At MIN marking or just above -2-
78
4. Descriptions of work
Tiguan 2016 ➤, Tiguan 2021 ➤, Tiguan RUS 2017 ➤, Tiguan RUS 2021 ➤
Maintenance - Edition 12.2020
“replenishing is NOT required”.
Recommended brake fluid level, brake pads new or well within
wear limit:
•
Between MIN and MAX markings
NOTICE
If the fluid level is below min. marking -2-, the brake system
must be checked for leaks before fluid is topped up, “Repair
measure”.
4.13
Dual clutch gearbox 0D9: changing
gear oil and filter
⇒ 6-speed dual clutch gearbox 0D9; Rep. gr. 34; Gear oil;
Draining and filling gear oil
⇒ 6-speed dual clutch gearbox 0D9; Rep. gr. 34; Gear oil cir‐
cuit; Removing and installing gear oil filter
4.14
Dual clutch gearbox 0DD: changing
gear oil
⇒ 6-speed dual clutch gearbox 0DD (hybrid); Rep. gr. 34; Gear
oil; Draining and filling gear oil
4.15
Dual clutch gearbox 0DL: changing
gear oil
⇒ 7-speed dual clutch gearbox 0DL; Rep. gr. 34; Gear oil;
Draining and filling gear oil
4.16
Dual clutch gearbox 0GC: changing
gear oil
– ⇒ 7-speed dual clutch gearbox 0GC; Rep. gr. 34; Gear oil;
Draining and filling gear oil
4.17
Diesel particulate filter: checking
– Check ash loading ⇒ page 31 .
4. Descriptions of work
79
2024 VW Tiguan Owner's Manual
